ERG 2024 · Guide 113

Flammable Materials (Wet/Desensitized Explosive)

UN3344 · Pentaerythrite tetranitrate mixture, desensitized, solid, n.o.s., with more than 10% but not more than 20% PETN

Also listed as: Pentaerythritol tetranitrate mixture, desensitized, solid, n.o.s., with more than 10% but not more than 20% PETN · PETN mixture, desensitized, solid, n.o.s., with more than 10% but not more than 20% PETN

Class 1

Explosives 1.1 placard (DOT 49 CFR §172)

CHEMTREC · 24/7

1-800-424-9300

Right now: Move upwind. Isolate 100 m minimum. Deny entry. Call CHEMTREC with shipping paper in hand.

More contacts →

Potential Hazards

Health

Some are toxic and may be fatal if inhaled, ingested or absorbed through skin. Specifically, Dinitrophenol, wetted (UN1320); Dinitrophenolates, wetted (UN1321), Sodium dinitro-o-cresolate, wetted (UN1348); and Barium azide, wetted (UN1571) are known to be toxic.
Contact may cause burns to skin and eyes.
Fire may produce irritating, corrosive and/or toxic gases.
Runoff from fire control or dilution water may cause environmental contamination.

Fire or explosion

Flammable/combustible material.
May be ignited by heat, sparks or flames.
DRIED OUT material may explode if exposed to heat, flame, friction or shock; treat as an explosive (GUIDE 112).
Keep material wet with water or treat as an explosive (GUIDE 112).
Runoff to sewer may create fire or explosion hazard.

Public Safety

General

CALL 911. Then call emergency response telephone number on shipping paper. If shipping paper not available or no answer, refer to appropriate telephone number listed on the inside back cover.
Keep unauthorized personnel away.
Stay upwind, uphill and/or upstream.
Ventilate closed spaces before entering, but only if properly trained and equipped.

Protective clothing

Wear positive pressure self-contained breathing apparatus (SCBA).
Structural firefighters' protective clothing provides thermal protection but only limited chemical protection.

Evacuation

Immediate precautionary measure
Isolate spill or leak area immediately for at least 100 meters (330 feet) in all directions.
Large Spill
Consider initial evacuation for 500 meters (1/3 mile) in all directions.
Fire
If tank, rail tank car or highway tank is involved in a fire, ISOLATE for 800 meters (1/2 mile) in all directions; also, consider initial evacuation for 800 meters (1/2 mile) in all directions.

Emergency Response

Fire

CARGO Fire
DO NOT fight fire when fire reaches cargo! Cargo may EXPLODE!
Stop all traffic and clear the area for at least 1600 meters (1 mile) in all directions and let burn.
Do not move cargo or vehicle if cargo has been exposed to heat.
TIRE or VEHICLE Fire
Use plenty of water - FLOOD it! If water is not available, use CO2, dry chemical or dirt.
If possible, and WITHOUT RISK, use unmanned master stream devices or monitor nozzles from maximum distance to prevent fire from spreading to cargo area.
Pay special attention to tire fires as re-ignition may occur. Stand by, at a safe distance, with extinguisher ready for possible re-ignition.

Spill or leak

ELIMINATE all ignition sources (no smoking, flares, sparks or flames) from immediate area.
All equipment used when handling the product must be grounded.
Do not touch or walk through spilled material.

Small Spill

Flush area with large amounts of water.

Large Spill

Wet down with water and dike for later disposal.
KEEP "WETTED" PRODUCT WET BY SLOWLY ADDING FLOODING QUANTITIES OF WATER.

First Aid

Refer to the “General First Aid” section.

Flammable Materials (Wet/Desensitized Explosive)

UN3344 · Pentaerythrite tetranitrate mixture, desensitized, solid, n.o.s., with more than 10% but not more than 20% PETN